Last week I had a chance to go back into the Connaught Tunnel – the Victorian railway tunnel that runs underneath two of London’s docks and will be part of the future Elizabeth line service.

As you may recall from my previous articles, two of the Docks have a water channel linking them, and a railway bridge was impractical, so the Victorian engineers built a cut/cover tunnel that runs underneath the short canal. Later used by the North London Line, it was mothballed in 2006, and is now being modernised for future Crossrail services.

Connaught Tunnel schematic

Although constructed in 1878, as boats above got ever larger, they started to scrape the top of the tunnel – and in 1935, the roof of the middle section was lowered and a new steel lined tunnel inserted into the space. This has to be removed as it is too small for Crossrail trains – and because the gap between steel and water has corroded away to such a degree that it is now quite unsafe.

Works on that will start next January when the canal above is sealed off, drained and the top exposed again to dig out the old tunnel and build its replacement.

I’ve been into the tunnel three times now – once just before it was handed over to Crossrail in this February and again last week. One of the engineers said I have been inside more often than he has.

Although the route and photographic locations are not exactly the same, there is a chance to compare vaguely similar areas and see how work is progressing.

Going into the tunnel

April 2011

Into the Connaught Tunnel

Feb 2012

Going into the tunnel depths

April 2012

The main work has been to remove all hint of previous railway infrastructure and then dig down to remove the ballast and start preparing to underpin the tunnel as the floor needs to be lowered for the larger trains that will use it.

Walking down the slope into the tunnel on a dry day and the site looked like any reasonable building site, but as we got deeper down, the extent of water leaking into the tunnel became apparent, with a small torrent of water flooding down the centre of the curved base. Pumps working to drain out the tunnel were struggling in places – apparently one was being temperamental that morning — so wading through deep puddles was the order of the day.

One of the rare times I am please to wear waterproof building site boots.

Collecting emergency oxygen packs before heading into the tunnels (yes, really!) and it is clear to my eyes how much ballast has been removed from the base of the tunnel as my shoulders were now roughly level with where the floor had been just a few months earlier.

Contemplating the gloom

One thing I quite liked, from a purely aesthetic perspective is how the cutting down through the brick has exposed it in a manner that looks not that unlike a sedimentary rock formation. Sadly, Victorian bricks of this era are really not the best quality and they are going to have to be very careful when cleaning the bricks that will remain exposed in the tunnel as they have a thin surface finish that crumbles under modern pressure cleaning techniques.

Cutting through the brick layers

The last time I was here, we were only allowed a short distance into the tunnel, but this time it was all the way down to the inserts where the brick tunnel was replaced with steel linings – yes, steel, not iron.

The brick narrow inserts

Not allowed to go deep into the steel inserts themselves, as works are still ongoing, but close enough to get some good photos of the structure that is to be removed.

Along the steel inserts

Back into the main tunnel to leave, and one thing which was visible in places were the quite lovely brick flooring that will have to be removed by the building works. I doubt the bricks are salvageable as they have been soaked for too long, but they made a pleasant tile effect as they peeked out from under the gravel and spoil heaps.

Brick floor detail

Works are also continuing above ground.

The old Silvertown station is to be removed in the next few weeks, and works will start on the pumping shaft I wrote about last week.

Further away, as the old railway runs towards Woolwich, loads of roadworks are being carried out at the moment to shift sewers and services in preparation for works to dig the sloping portal that will lead to a newly constructed tunnel under the Thames.

Silvertown station - what's left of it.

April 2011

Old Silvertown station

April 2012

More photos from April 2011, Feb 2012 and last week’s visit. Thanks as usual to Crossrail and Vinci Construction for putting up with me.

NEWSLETTER

Be the first to know what's on in London, and the latest news published on ianVisits.

You can unsubscribe at any time from my weekly emails.

Tagged with: , ,
SUPPORT THIS WEBSITE

This website has been running now for over a decade, and while advertising revenue contributes to funding the website, it doesn't cover the costs. That is why I have set up a facility with DonorBox where you can contribute to the costs of the website and time invested in writing and research for the news articles.

It's very similar to the way The Guardian and many smaller websites are now seeking to generate an income in the face of rising costs and declining advertising.

Whether it's a one-off donation or a regular giver, every additional support goes a long way to covering the running costs of this website, and keeping you regularly topped up doses of Londony news and facts.

If you like what you read on here, then please support the website here.

Thank you

7 comments
  1. Kit Green says:

    Are the trains really bigger or is the tunnel floor lowered to give room for the overhead power equipment?

  2. Syniq says:

    Blimey. I had no idea Silvertown had gone already, otherwise I’d’ve wobbled down there to get some photos before it was removed. It’s kind of a shame, really, ’cause the trees and things on the platforms looked pretty good – kind of how Cane Hill near where my parents live looked before they tore it down instead of restoring it after some tw-t torched it. 🙁

    Changing the subject entirely, you’ve got more experience with this stuff than I have. I’m trying to create 3D models of various underground stations for a game I’m creating and I’ve got a bit of software to do it automatically from photographs, but I have no idea if LUL are up for that sort of thing. (Maybe they’d be more up for it if we give them the models once they’ve been created?) Any ideas how to go about getting permission to do it? :/

    • IanVisits says:

      You would have to contact their intellectual property team and discuss it with them.

  3. Andrew Thomas says:

    I remember travelling on the North London Line in this area (foot tunnel or ferry over from Woolwich to North Woolwich). Shame that Silvertown station gone now ….. but at least Tate and Lyle is still there … hahahahaha

  4. Andrew Thomas says:

    i’d love to go through that tunnel myself (if i can avoid the aeroplanes coming in)

  5. Did you know that the track from the section of line through Custom House station to the tunnel was recovered and is now laid as the tracks through North Weald station on the preserved Epping Ongar branch?
    Indeed several of the points are in use at North Weald with the same point machines! While on-site we also ventured down the tunnel, which had a float switch in the bottom linked to a indicator to tell the signalman when it was getting too deep / pumps not coping so trains could be stopped until the waters had dropped! :o)
    Passengers can once again travel over former Custom House rails when the railway recommences steam services on the branch from 25th May (discounted tickets available to purchase from our website: http://www.eorailway.co.uk)

Home >> News >> Transport News